EPOXY FLOORS
IN WOODBURY, MN
Woodbury built out heavily through the 90s and 2000s, so the typical garage slab we coat here is 15 to 30 years old. That age means the standard mix of suburban wear: drip-line salt scaling, hot tire pickup, and joint movement from years of freeze/thaw.
Local Concrete Notes — Woodbury
WHAT WE SEE
ON WOODBURY SLABS
Woodbury built out primarily from the late 80s through the 2020s, with a heavy concentration of 1995 through 2015 construction. That makes the typical slab here 10 to 30 years old — usually in solid structural shape but showing the standard suburban issues: salt scaling at the overhead door, hot tire pickup in the parking footprint, joint movement, and minor shrinkage cracking. The newer pours in developments like Bailey Hills and Stonemill Farms still carry curing compound that has to come off. Walkout patios and lower-level slabs are common here and need moisture vapor consideration before any coating goes down.
On a walkout slab, we always run a moisture vapor test before quoting the system. If the slab is putting up vapor, we adjust the primer chemistry — putting a non-vapor-tolerant coating over a wet slab is one of the fastest ways to end up with bubbling and delamination.
- Salt scaling and chloride saturation in the drip-line zone of attached garages
- Walkout patio slabs often need vapor testing and a vapor-tolerant primer
- Newer subdivisions need curing-compound removal before bonding
- Diamond grinding on every job — no acid wash, no shortcuts
- Sherwin-Williams industrial epoxy and polyaspartic products
- 10-year written warranty on every installation
Service Areas in Woodbury
NEIGHBORHOODS
WE SERVE
Woodbury is Washington County's largest city and grew primarily through the 1990s and 2000s. The city is notable for its large attached garages — three-stall configurations are common even on mid-range homes — and walkout slab construction is widespread due to the hilly terrain east of I-494. Walkout lower-level slabs and patio concrete are a significant part of our Woodbury work.
Local Area
SERVING THE
WOODBURY AREA
We are a local Minnesota company. If you can see any of these landmarks from your property, we are in your neighborhood and work here regularly.
- Colby Lake Park
- Tamarack Village
- Woodbury Lakes Shopping Center
- Carver Lake Park
- Bielenberg Sports Center
- Radio Drive commercial corridor
FREQUENTLY ASKED
QUESTIONS
Woodbury-specific questions we hear often — answered straight.
We're in Stonemill Farms. The house was built in 2004. Does a 20-year-old slab need significant prep?
A 2004 slab in Stonemill Farms is in the age range where real wear starts showing up — drip-line scaling near the overhead door, control joints that have widened slightly, and the start of hot tire pickup. The prep is typically moderate: full diamond grind, joint treatment, minor crack or pitting fill, then the coating system.
Our Woodbury home has a walkout lower level. Can you coat that slab too?
Yes. Walkout lower-level slabs in Woodbury are a regular part of our work. We run a moisture vapor test first — below-grade slabs in this area commonly show some vapor transmission. Based on results, we select either a standard or vapor-tolerant primer before installing the coating.
Is polyaspartic or epoxy better for a Woodbury garage?
The correct answer is both — used together as a system. We apply an epoxy base coat broadcast with full-chip flake, then seal it with a polyaspartic topcoat. The epoxy builds the thickness and decorative layer; the polyaspartic provides UV stability, chemical resistance, and the hard topcoat finish that wears for years.
Do you service the Radio Drive commercial corridor in Woodbury?
Yes. We do commercial floor coatings on the Radio Drive and Bielenberg Drive commercial corridors in Woodbury. Office, retail, and light industrial slabs all come through that zone regularly, and we work in Woodbury year-round.
ALSO SERVING NEARBY CITIES
READY FOR A NEW FLOOR
IN WOODBURY?
Free quote, no pressure. Benjamin Buckner or Mitchel Lovett — the co-owners — will walk the slab with you, talk through what it needs, and write a real number on the spot.